Mga Pamantayan sa Pagpapanatili ng Chain ng Transmission

Ang Kadena ng Transmisyon ay isang napaka-kritikal na istraktura ng paghahatid sa mekanikal na kagamitan, na nakakaapekto sa pagganap ng trabaho at buhay ng serbisyo ng kagamitan. Samakatuwid, ito ay lubhang kinakailangan upang mapanatili ang kadena sa mga ordinaryong oras.

1. Ang sprocket should be installed on the shaft without skew or swing. The end faces of the two sprockets in the same assembly should be in the same plane. When the center distance of the sprocket is less than 0.5 meters, the allowable deviation is 1 mm; when the center distance of the sprocket is more than 0.5 meters, the allowable deviation is 2 mm. However, it is not allowed to rub the side of the sprocket tooth. If the two-wheel knitting is too large, it will easily cause chain disconnection and accelerated wear. When replacing the sprocket, check and adjust the offset.
2. Ang tightness of the chain should be appropriate. Too tight increases power consumption and bearings are easy to wear; too loose chain is easy to jump and fall off. The tightness of the chain is: lifted or pressed down from the middle of the chain, the center distance between the two sprockets is about 2%-3%.
3. Ang chain is too long or stretched after use, and it is difficult to adjust. You can remove the chain-link depending on the situation, but it must be an even number. The chain link should pass through the back of the chain , the lock piece should be inserted outside, and the opening of the lock piece should face the opposite direction of rotation.
4. Matapos masira nang husto ang sprocket, dapat na sabay na palitan ang bagong sprocket at ang bagong chain upang matiyak ang magandang meshing. Hindi pwedeng magpalit lang ng bagong chain o bagong sprocket. Kung hindi, magdudulot ito ng mahinang pag-meshing at mapabilis ang pagkasira ng bagong chain o bagong sprocket. Kapag ang ibabaw ng ngipin ng sprocket ay nagsuot sa isang tiyak na antas, dapat itong ibalik at gamitin sa oras (tumutukoy sa sprocket na ginamit sa isang adjustable na ibabaw). Upang pahabain ang oras ng paggamit.
5. Ang old chain cannot be mixed with part of the new chain, otherwise, it is easy to have an impact on the chain and break the chain.